1984 AMC Jeep CJ7 Restored, Fiberglass Body

Description for Jeep CJ 1984

1984 Jeep CJ 7

Fully restored with clean Michigan title

. New Shell Valley-Kevlar & Fiberglass tub, front fenders and hood.

Stock tail gate, grill, windshield, dash and half doors.

1 Frame

Striped, cleaned and painted. Body mounts repaired where needed.

2. Front axle assembly

Cleaned, pained and new Gear Lube. New: axle U-joints with Zirk Fittings, axle bearings & seals, wheel bearings & seals, rotors, calipers & pads, and brake hoses. Lock out hubs cleaned and new lube.

3. Rear axle

New: bearings, inner and outer seals, wheel cylinders, brake hardware, shoes, drums

and parking brake cables

4 Front and rear drive shafts

Checked for balance and new U-Joints with Zirk fittings.

5 Transfer case

Inspected, cleaned, painted with new seals & gear lube

6. T 5 manual Transmission,

New: front seal, bearing, clutch & presser plate. Flywheel resurfaced.

7 258 Inline 6 Cylinder.

Cylinders are honed. Installed new ring bearings (rods & mains), Valves lapped and installed new valve seals. New oil pump, water pump, seals and gaskets. Inspected, Cleaned and painted intake and exhaust manifolds. Installed new exhaust from front header pipe to tailpipe. New flowmaster muffler single inlet dual outlet with dual tail pipes (must hear to appreciate. Installed new radiator, upper and lower hoses. Installed new heater supply & return hoses, vacuum lines. Installed remanufactured carburetor with new chrome K&N air cleaner.

8. Steering

Installed remanufactured power steering box and lines. Power steering pump psi verified and installed new seals and fluid

Ball joints & tie rod ends checked and are good shape. Installed new steering shaft coupler at steering box. Steering column has new lower bearing. Column has been cleaned and painted.

9 Brakes

Installed new master cylinder. Installed new steel lines front to rear. Brake booster cleaned, painted and new bushings installed.

10 Fuel tank

Removed, cleaned and painted. Installed new skid plate, tank-strap, fuel fill hose, vent hose and steel fuel lines from tank to engine. Sending unit is in good shape and is resealed.

11 The Body & Interior

Factory Red Gelcote Finish, Kevlar & fiberglass body front fenders and hood. Stripped, Cleaned and painted to match: grill, doors, windshield frame, tail gate, dash & roll bar.

The roll bar has been up graded to a 6 point mount from a YJ. Also installed front and rear sholder harnesses and pads.

Installed all new stainless steel hood, door, windshield, and tail gate hinges. Also, all matching S.S. bolts.

Removed and cleaned heater box, air doors and all moving parts. Installed new cables up graded heater

blower motor to provide more air volume that will blow good heat and defrost. The pedal assembly was removed, cleaned and painted. Also, installed new brake and clutch bushings.

All wiring reloomed. Installed all new lights: rear, front and dash. Installed new wiper povits, links, arms & blades. Installed new Corbeau front seats. New Best-Top soft top and steel half doors. Installed new stainless steel kick plates at doors. Installed new radio & speakers. Installed new glove bo, New exterior mirrors and rear view mirror.

The is a very nice Jeep CJ7 that is 33 years old. It has not been used off road, stored in the winter. (since restored) Please note it rides like a jeep, It is not going to ride like a Cadillac. It is not a speed demon with a 258 straight six, but has lots of torque.