1994 Land Rover Defender D90 NAS - full "nut and bolt" rebuild just completed

"Blue Jay”

This is a truly one-of-a-kind 1994 Land Rover Defender 90 NAS, no. #275 of approximately 1900 that were brought to the US market between 1993-1997.

A full "nut-and-bolt" rebuild has recently been completed by HHH Heritage, who are highly regarded as one of the most detailed Defender builders in the US.

This build pays homage to the world renowned design of the Defender, while the never-ending list of improvements, updates, and customization has revived this vehicle for 2019 and beyond.

Over $138,000 was put into this vehicle, with no stone left unturned and no expense spared. Each of the 550 labor hours was committed to ensuring mechanical and aesthetic perfection both internally and externally.

Very reluctant sale due to arrival of a 2nd child and subsequent home-build since starting the build in July 2018. Build was completed in June 2019.

Due to the extensive nature of the build, the work completed has been divided below.

The below is a list of what was completed, but not limited to, throughout the build.

Chassis:

Galvanized chassis replacement (painted black)

Engine:

Complete rebuild of the original 3.9L fuel injected V8 engine
Fuel injection pump rebuild

Alternator rebuild

Starter rebuild

Water Pump

Fuel injectors

Ignition set

Radiator and hoses

Wiring set
Viscous drive unit

Fan Belt

Manifold bolts extract/Clean

Accelerator cable

Distributor

Underside:

New suspension throughout - shocks & springs, sway bar, turret kit

Reconditioned front and rear axles, replace wheel bearings, seals, hub gaskets and fluid

Replace front and rear brake calipers, discs and brake shields restore and replace brake lines

Transmission and transfer case check and reseal/cleaned and painted

Exhaust (stainless steel)

Brake rod set (Emergency Brake)
Fuel lines replaced as needed

Prop shafts - Front & Rear

Rear ball joint (Wishbone)

Track rod

Steering joints - upper and lower

Transmission brake drum cable

New bushings

New front casting arm

New swivel ball and seal replacement front axle both sides

Steering box

Support bar frame

Front Sway bar

Hub bearings

Rear arm mounting brackets

Clutch Assembly/cover

Clutch release bearing

Transmission brake drum

Front steering damper

Ball joint assembly

Body:

Tub repairs/ top caps

Wings/hood/cowl repairs

Bulkhead repairs/welding

Exterior:

Full re-paint in original Arles Blue - body was removed for painting

Custom built roll-cage - powder coated - with hand sewn custom padded soft-top
Original wheels restored and wrapped in new BF Goodrich tires
Wheel spacers added and new black alloy lug nuts

New Front Doors - with new sliding windows and tracks

New Tail gate door

New Windscreen and seals

Rubber mat/coating in the rear rub

Full LED light kit - headlights, tail lights, side lights

KBX front grill

New doors handles, shocks, brackets, plates

Rear step bumper

Wing protectors

Running boards

Header rail for soft top

New mirror assemblies

Interior:

Puma dash upgrade with touch screen navigation and rear back-up camera

Re-covered seats and new mat set throughout

Custom A/C and heater installation/diagnostic with custom lines, compressor, drier (built for TN summer)

Matrix heater

New seatbelts and brackets throughout

Cubby box

Pad foam shifter

Misc:

Cleaning, blasting, power coating of parts

Vent seals

Hood Seal

Check straps

Hood hinge slides

Front and rear bump stops

Rear stub axle oil seal

Cross-brace LH grille top

Front roll cage gaskets

Bulkhead drain

Cap-fuel tank filler

Finisher LH & RH

Delivery is available within the US at buyers cost.

Confidentiality will be fully respected if requested by inquirer.

Please ignore the zero feedback - each vehicle receives it's own eBay account - please find us @hrhimports on Instagram or www.hrhimports.com